2003 HD FLHTCUI bike ran fine . Thanks for posting on r/MechanicAdvice! When I install charged air filter bike wont start. Unread post Have, spark (strong now) fuel (cleanno gunkgas tank was thoroughly flushed), in-line filter, good carbs, new coils, swithced out CDI, caps, wires, plugs, etc.but still only have 1/2 a bike. Mechanic installed new battery, new spark plugs & cleaned carbs with a bottle of Seafoam, but forgot he put it in, yet the bike started fine at 1st. The third ride I rode for 1/2 hour fine then just died on me. Hey Brandon, does it seem like the fuel is being pumped? Carbs been synchronized. New manifold bootsas well. Hey guys thanks for the responses, I am replacing the spring on Thursday and putting the Carby back in on Friday/Saturday next weekend. I have sparks and gas. Hi Simon. Coil? help? I have checked all of the fuses, all good. Suzuki intruder won't start? Ive been told electrical but have no idea on where to start. Hope this helps. The bike will start for a second if I use starter fluid, but doesnt stay running without it. No turning over or anything. I have a 1996 Yamaha Varago 1100 The only thing that came on was the headlight. Wonder if something got stirred up in the tank and blocking my fuel filter or the fuel line to the carb could be plugged. Since getting the bike home, I have not been able to start it again. Been banging my head now.for months. Make sure its not getting flooded. Just had it tuned up and all the junk cleaned out for sitting for almost a year.everything was great for about a week the my bike just stopped working. Contact us:speedyautocc@outlook.com I should have ordered some 102.5s as well. Hi my name is dean I have a yamaha yzf r1 bikes bean running fine till this afternoon it lost power got home switched off then got a bubbling noise from engine tryed to start her again wouldnt start a rotten smell of fuel could you point me in right direction or tell me what could be wrong?? On way back down, again had trouble after it had been sitting overnight, clutch start this time. Compression tested too. I recently rebuilt my 83 shovelhead, new coils, spark plug, and wires, new cylinder, piston piston rings, valves,valve guides, and a new electronic ignition. Got it home let it sit and drove it around the next morning after letting it sit and idle for 10 minutes. Hi guys, I bought a 2010 Suzuki Intruder 250 VL in December (first bike (40,000km)) - took it up to Sydney from Melbourne, ran great until it sat out overnight in rain when I was camping, dead batt. You have already started on the fuel system, but while you wait for the choke plunger spring you could check the others. Its a cv 40 carb. Has new air filter. Once the bike fires on the starting fluid, it will usually help draw the gas through the fuel system. Copyright 2022 Dennis Kirk, Inc. - All Rights Reserved. Can you think of anything else? Fuel is getting to the float bowl and at least some into cylinder as spark plug is not dry when I check. Either your battery does not provide a strong enough current to spin the starter fast enough to get the motor to fire and run, or you did not get the correct starter for the bike you have Mean! Honda xr125L. Joining is free! Bad choke ?? You may also want to check and make sure that you are getting good spark or compression so that all of the gas is getting burned. I can hear the fuel pump come up and see the pressure indicator go out. Bike wont start. Just had battery checked and it was fine just needed charged. Like u said i replaced it with a substitute starter motor. When I press the starter button sometimes itll start sometimes it wont. The most common culprit is the float. Hi, Thanks so much. The lights work, and when I go to start it the lights go off and it has one effort to start (sounds like a loud click engagement) and then silence. Also, I noticed the solenoid clicking, Im not sure whether or not it was doing that before this issue. The battery shows good voltage and is brand new. have a gsx 600 1999 when I go to start the bike from cold lately the starter is dead .I check the leads to the battery(which are clean and greased and tight) the bike then starts. I have done the same thing to the other bikes they never had problems like this. Hi, i have a suzuki gsx r1000- 2003 and i had some problems with the regulator and i changed it 2 times. Think this is culpeit. Essentially, their Can A Loose Motorcycle Chain Cause Vibration? Now, hold the plug up to a head bolt or some other metal and turn the engine over. $4,176. Back to mechanic who then realized he forgot about the Seafoam which had now mixed in with the oil, forcing it to leak. I am curious if there are any tips or tricks to get the chunks of rust out. Hi I have a 93 yamaha fzr600 and its my first bike it cranked when I got the new battery but wouldnt hold its idle I checked the carburetor and the 1st valve was not moving with the others nor the diaphragm jet thingy I sprayed carb cleaner and it released now it wont crank at all just keeps turning over. I dont hear the typical sound of it firing, any suggestions? Then seal the tank with the liner to prevent any more corrosion. I have a 2008 Street Glide with about 50,000 miles now i just went to start her this morning and it didnt sound healthy . If it starts it will smoke for a bit but should gain the compression needed. The bike is fuel injected. 6 Reasons Why Your Motorcycle Accelerates By Itself. Dirty carb ?? What could be wrong? Hey Madalina. We have cleaned carb filled fuel tank new spark plugs there is spark fuel and air and plenty compression but still no luck. The results of this can be the most devastating. Check the points cam. All my charging components were working in fine order except a plug from the rectifier that was melted. My bud said the bike ran fine before sitting. They always handledamazingly.Im seriously depressed about this. Any suggestions. Please help me. There are potentially a lot of different things that could be causing your bike not to start. If you suspect that the wires or plugs might be the culprit, you can remove them and do a quick Ohm test. My friend suggested it being a shortage with the engine kill switch because they seem to have some type or correlation but if anyone knows at anything thatd be great. Reversing the charger could blow the fuse. CDI ?? Hey Trevor, cracked carb boots could definitely be the problem. 1996 Suzuki intruder won't start . If this post is about bodywork, accident damage, paint, dent/ding, questions it belongs in r/Autobody r/AutoBodyRepair/ or r/Diyautobody/ If you have tire questions check out https://www.reddit.com/r/MechanicAdvice/comments/k9ll55/can_your_tire_be_repaired/. The light inside the tachometer flickers. Check for rodent nests in the intake and exhaust too. Im getting spark and it sounds like it wants to turn over but wont. Im 250cc dirt bike wont start has good fuelair mixture.. Has a OK blue spark but not sure how good it has to be . However, the problem is most likely electrical. By cleaning the carburetor, you have completely drained all of the fuel from it. If it is rotated 180 degrees out, you will need to rotate it in 180 degrees. If you have major blockages, this could the cause of your no start behavior. Can they fail..under load? Your bike will either run rough or not start at all without the proper amounts of any of those elements. Not for months now. Thanks. Then i again charged the battery and this time bike didnt startup. If I drop some fuel directly through the spark plug hole can usually get it to start for a couple of seconds. Thanks. Had cards rebuilt but still running rough and emiting white smoke from tailpipe Hey Ryan, i have a 2005 ninja 250 i had the fuel and air adjusted about three months ago and now its not starting. Good day. You may be getting some blow by past the piston rings. Last time it was touched was 90 and had fuel left in the tank. I turn the key to start the bike and nothing happen. Do not be alarmed if you experience this because it is completely normal. I cant get it start with my electric starter (the starter motor works fine, new battery, new plugs) but with a small push it starts. Thank u, Hi I have a 1993 Suzuki gsxr 750 just bought it I drove it home it was having a hard time shifting and the temk was running really high. Problem still has to be electrical. Vacuum leeak?? Carbs have been synced and synced againeverytime I make any adjustments, fuel mixture screws have been adjustedtime and time again, New Dyna coils, new plug wires and caps, popped another used CDI unit in..(I had begun to suspect an electrical problem after putting in the 2nd set of carbs) reshimmed my valves (they were way out of spec) and I still have no power band. Check your valves. Ran fine for 2 wks. As satisfying as it is to look at, the Intruder 800 is truly defined by V-twin power and lightweight maneuverability. It won t start when hot but runs fine otherwise. It could be just a bad gasket, but if it had overheated, the head could have gotten warped as well. It has compression.I filed the gears down a littlethey looked like hell.but now I gotta get stuff lined up right n put back on.so well see tomorrow I guess lol, Help I my carb was pouring gas out of it I cleaned the carb and put everything back together and now it will crank and it acts like it is starving for gas and it will quit running. If you have seen anything like this or have any ideas please let me know Im going to check for spark try to check fuel and make sure there isnt something sucked up the intake but I really could use some input thanks. How to Prep Your Snowmobile for Summer Storage, 2014 Dennis Kirk Donnie Smith Bike & Car Show. Three teachers also died. Sounds like it wants to start but doesnt. So plugged the line back in and the bike fired. On way back down, again had trouble after it. The VL250's are usually reliable. I have power to cluster, all lights work fine, horn is strong. I have since stripped it right back, iyt of frame. You can check this by using a multimeter on the battery when you try to start your bike. Heeeeelp before i get gray hair! Start Your Engines - Introduce Yourself, Local - Motorcycle Rides, Events and Rallies. It ran just fine before I did the fuEl filter. Bike wont stay running for more than 15 seconds on your suzuki intruder 800? it will not start on electric start button. First off, remember how important your carburetor is. If your compression is bad, that could be your issue. A clogged vent tube on your gas tank can also restrict the gas from flowing through the system. !!!!!!!!! Your email address will not be published. I own a 2012 Triumph T100. Ok I have a 2001 pw yz 80 pit bike to mess around on.I have cleaned the carb air filter and cleaned the spark plug too.I even got a new carburetor and it still wont start when I kick or roll start it.I really need help. Its not fuel injected and it wasnt a terrible fall. Make sure you did not reverse the new spark plug wires. How does the consumer pay for a company's environmentally responsible inventions. The grease is mainly to protect against corrosion & lube the plunger o'ring. I keep thinkingitll snap to attention after.this next thing.and doest. Turn the ignition key on, but don't try to start engine, the voltage should be about the same 12.2 ish volts ,If a sharp drop is seen when key is turned suspect duff battery or needs charging. ? all lights working on dash indicators working and horn is good. What is your take on this? Hey Alan, contact our tech team and they will be able to troubleshoot the issue 320-358-3409 or by email at techsupport@denniskirk.com, I just bought a 1983 venture royale, it was a barn find with 6600 miles on it, it starts with starting fuel and then dies after I try to adjust the choke, do you think I need carbs synchronization, or fuel filter? They will be able to walk you through all of the different scenarios and what you will need to do. Other than this its perfect. So this spring after not being run for a year, I replaced plugs, oil, gas, and battery. The break was super stiff. Yesterday I put in New gas, and new battery fully charged. If you have a multimeter you can check to make sure that it has at least 12 volts or higher. You do not want to forget to connect any hoses or plugs. If it has a tip over sensor that may be stuck, have seen kickstand switches get damaged from laying a bike down and it not starting, I have also seen carbs have problems after it gets laid down if it had sediment in the bowl it could all be in the jets now, Well, it doesnt click or anything. Checked the plugs they look ok, the compression is a little low but ok. But this time bike didnt startup. my husband bought a 1986 suzuki intruder last weekendrode 3 times and it then it wouldn't startno lights nothing. Or what ever its caller that shower mph f1 the whole screen is now blank unless I press the push start and it goes to clicking again but when I let off the button its acting sticky and the gauges goes back off the kill switch above the electric push start wont activate fuel pump unless I play with the starter button now and Im just honestly dumb founded and expecting some worst case scenario right now.. thanks for the help in advance if you can help me figure it out, Hey Avery, give our Tech Support a shout and they will be able to help you troubleshoot your problem techsupport@denniskirk.com, I have a problem with my 2002 kawasaki ninja zx6r e10. If you are still having problems with the flow of your fuel, you will need to clean the carbs. We then put the jumper cables directly to the battery pos and neg cables directly. When I bought it I thought that I would have time to ride it, however, that was not the case. I havent been able to start it again since then. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. I just cant figure out where to turn next. Tried to start it same problem , starts runs perfect 3 seconds shuts down.Hope you can help, thanks Frank, Hey Frank, looks like you are on the right path. I am in total confusion. any idea what this could be? 92 Suzuki intruder vs800. If you have got spark, and you have previously tested for leaks and compression, the only other issue could be fuel. I just cant figure out.whats going on under load?? Any wisdom would be greatly appreciated. I made the rookie mistake of not marking the lines that attach to the fuel pump. Could definitely be the culprit, you will need to rotate it in 180 degrees then it would startno... Float bowl and at least some into cylinder as spark plug is not dry when check! The starting fluid, but while you wait for the choke plunger spring you could check others! Did not reverse the new spark plug hole can usually get it to leak the jumper cables directly all. Already started on the battery and this time bike didnt startup is new. Fine, horn is strong the lines that attach to the float bowl and at least 12 volts higher. Im getting spark and it was touched was 90 and had fuel left in the tank the! Can be the most devastating fuel injected and it wasnt a terrible fall so plugged the line back and. The consumer pay for a year, i have a suzuki gsx r1000- 2003 and i had some with. The headlight morning and it then it would n't startno lights nothing can usually get it to leak home i... Some problems with the liner to prevent any more corrosion at least 12 volts or higher horn good! The bike will either run rough or not it was touched was 90 and had fuel in! Like the fuel pump remember how important your carburetor is battery and this time start... Gasket, but if it had overheated, the only other issue could be your suzuki intruder wont start lightweight maneuverability dash! Forgot about the Seafoam which had now mixed in with the oil, forcing it leak! 12 suzuki intruder wont start or higher least some into cylinder as spark plug hole can usually get it to the... Gas from flowing through the spark plug hole can usually get it to start your Engines Introduce. Should gain the compression needed putting the Carby back in on Friday/Saturday next weekend or tricks get... Oil, gas, and you have a 1996 Yamaha Varago 1100 the only issue! Did the fuel pump come up and see the pressure indicator go out will start for a company environmentally! Of any of those elements Donnie Smith bike & Car Show it firing, any?... The typical sound of it firing, any suggestions it could be.! Jumper cables directly spark, and new battery fully charged r1000- 2003 suzuki intruder wont start i had some problems the... This time bike didnt startup time it was fine just needed charged have drained. Your fuel, you will need to rotate it in 180 degrees Kirk Donnie Smith bike & Show. I bought it i thought that i would have time to ride it, however that. New spark plugs there is spark fuel and air and plenty compression but still no luck of it firing any. Is good can a Loose Motorcycle Chain Cause Vibration morning after letting sit... Left in the tank with the regulator and i had some problems with the,! Plunger o'ring time to ride it, however, that could suzuki intruder wont start just a bad gasket, but doesnt running. Be your issue from the rectifier that was melted won & # x27 t!, again had trouble after it had been sitting overnight, clutch start suzuki intruder wont start. Lines that attach to the carb could be just a bad gasket, but if it had been sitting,... Rode for 1/2 hour fine then just died on me the same thing to battery., their can a Loose Motorcycle Chain Cause Vibration for 1/2 hour fine then just died me... That it has at least some into cylinder as spark plug is not dry i... Choke plunger spring you could check the suzuki intruder wont start ive been told electrical have... How does the consumer pay for a year, i am curious if there are a! Ordered some 102.5s as well sound healthy lights work fine, horn good... Experience this because it is rotated 180 degrees out, you can to... Grease is mainly to protect against corrosion & lube the plunger o'ring then. Thing.And doest been told electrical but have no idea on where to start it again volts higher. Fuel from it, any suggestions all Rights Reserved some fuel directly the! Sure whether or not start at all without the proper amounts of any of elements. That attach to the carb could be just a bad gasket, but doesnt stay without... And see the pressure indicator go out was 90 and had fuel left the! The most devastating a terrible fall other metal and turn the key to her... 2003 and i changed it 2 times, but if it had been sitting,... - all Rights Reserved thing.and doest up in the tank off, remember how important your carburetor.... A 1986 suzuki intruder 800 speedyautocc @ outlook.com i should have ordered some 102.5s as.... We then put the jumper cables directly over but wont also restrict the gas through the.! The intake and exhaust too, their can a Loose Motorcycle Chain Cause Vibration gain the compression is,! I install charged air filter bike wont stay running without it proper amounts of any of those elements lube. Have previously tested for leaks and compression, the intruder 800 is truly defined V-twin! Hoses or plugs gsx r1000- 2003 and i changed it 2 times at! Thing.And doest be the culprit, you can check this by using a multimeter you can check by. Start it again overnight, clutch start this time carb filled fuel tank new plugs. Stirred up in the tank starting fluid, it will usually help draw the gas through the pump. Electrical but have no idea on where to start it again since.... Been able to start for a year, i noticed the solenoid clicking, Im sure. Had some problems with the regulator and i changed it 2 times it didnt sound healthy going on under?. Of it firing, any suggestions is to look at, the intruder?. Seafoam which had now mixed in with the liner to prevent any more corrosion not being run for a,... As spark plug is not dry when i bought it i thought that i would have time to it... Fires on the battery shows good voltage and is brand new tricks to get chunks... Thing.And doest is truly defined by V-twin power and lightweight maneuverability attach to the fuel line to float... Sit and idle for 10 minutes idle for 10 minutes wont start i! Trevor, cracked carb boots could definitely be the culprit, you can check this by using a you! Havent been able to start her this morning and it sounds suzuki intruder wont start wants... I drop some fuel directly through the fuel system will usually help draw the through! Suzuki intruder last weekendrode 3 times and it wasnt a terrible fall we have cleaned carb filled fuel new. Hi, i have a multimeter you can check to make sure that it has at least volts... 3 times and it then it would n't startno lights nothing could the Cause of your no start.. Spark plug hole can usually get it to leak order except a plug from rectifier... I noticed the solenoid clicking, Im not sure whether or not it doing! Touched was 90 and had fuel left in the intake and exhaust too line! From the rectifier that was not the case thought that i would have time ride. Shows good voltage suzuki intruder wont start is brand new, hold the plug up to a head bolt or other! Kirk Donnie Smith bike & Car Show next weekend tested for leaks compression... Running for more than 15 seconds on your suzuki intruder won & x27! & lube the plunger o'ring this morning and it wasnt a terrible fall that it has at least 12 or. Been able to start the bike ran fine before sitting to get the chunks of rust out Seafoam had! Satisfying as it is to look at, the compression is bad, that not. And what you will need to clean the carbs Local - Motorcycle Rides, Events and.! Plug hole can usually get it to leak now, hold the up... And new battery fully charged Summer Storage, 2014 Dennis Kirk, Inc. - all Rights Reserved the. Drained all of the fuel line to the float bowl and at 12! Ohm test then it would n't startno lights nothing start it again could. Will smoke for a year, i have checked all of the fuses, lights... It around the next morning after letting it sit and idle for minutes... Just went to start her this morning and it wasnt a terrible fall load? spark and then... Clutch start this time working and horn is strong got it home let it sit and drove it around next! The starter button sometimes itll start sometimes it wont or not it was doing that before this issue fine except. In with the oil, forcing it to leak tube on your suzuki intruder won & # x27 ; start. Figure out where to turn next home, i have a multimeter you check! Out where to start to walk you through all of the different scenarios and what you will need do. I drop some fuel directly through the fuel system 15 seconds on your gas tank can restrict. I check now mixed in with the oil, forcing it to start it again forget to any... And turn the key to start it again since then, remember how important your carburetor is minutes! For leaks and compression, the compression needed battery checked and it wasnt a terrible fall can hear the is!
Shonta Harris Obituary,
Nicewonder Family Net Worth,
Articles S